Water treatment plant for chicken farm
Automatic water treatment for the demineralised water production. Demineralized water is used for high pressure cooling and humidification of air on chicken farm.
Water treatment plant for cosmetics production
Automatic water treatment plant for the production of demineralized water. Demineralized water is used to make cosmetics products.
Iron removal plant for beer production
One of the oldest breweries in Ukraine “Berdichev Brewery” improved their production by installing a new iron removal plant by SILHORKO-EUROWATER, based on ecological friendly non-chemical solution.
Independent water supply for laundry
In the laundry industry, a reliable and cost effective water supply is a crucial element to an optimum operation. In order to be independent from the public water supply, this laundry has established its own 60 m³/h filtration system for removal of iron and manganese from a ground water source.
Modernisation of iron removal system
Every year more than 100,000 cubicmetres of clean drinking water is distributed to about 900 households in the city of Østbirk, Denmark. The raw water is groundwater from four boreholes, 80 meters deep. The water treatment capacity has been enlarged and the water treatment technology has been modernised.
Waterworks for 2 x 25 m³/h of potable water
The Danish part of the SILHORKO-EUROWATER group has supplied a turnkey waterworks with a yearly capacity of 200,000 cubic metres of pure drinking water. The water treatment solution consists of two complete treatment lines, each with two pressure filters for removal of iron, manganese and ammonium as well as a clean water tank in stainless steel. T...
Reverse osmosis unit in sanitary design
Sanitary reverse osmosis unit in AISI 316L for the production of 12.5 cubic meters of demineralized ingredient water per hour. The customer is Danone.
Water softening (Ion Exchange) in municipal drinking water treatment
As the first water utility in Denmark, TÅRNBYFORSYNING is providing softened drinking water to its consumers using ion exchange technology.
Water treatment for Turkmenistan Glass Factory
The glass plant is designed to produce several types of glass products, including laminated and tempered glass. The DI water production is done in several steps, including double-pass membrane filtration. A special coating process requires water quality with low silica content and conductivity less than 1 µS/cm. Within each glass rinse zone, the wa...
New dealkalizer for French brewery
The customer is a French brewery with a yearly beer capacity of 100,000 hectolitre. To improve the water treatment process, the brewery has replaced an old dealkalizer by a new duplex plant including UV disinfection unit and pumps with frequency inverter for energy saving.
DI water for chromium-free pre-treatment
The pretreatment system performs cleaning, rinsing and preparation of the product surface. The purpose of the pretreatment system prior to powder coating is to ensure corrosion protection, optimal adhesion to the subsequent coatings, electrical insulation and minimize surface friction and abrasion. The rinse water is demineralized water, recirculat...
DI water for pre-treatment of light alloy wheels
The customer is a large European manufacturer of high-quality light alloy wheels. In order to fulfil the highest standards, proper pre-treatment plays a critical role. Each of three independent lines consists of gravel filter and two parallel demineralizers for continous operation.
DI water for rinse zones in surface pre-treatment of alloy wheels
The alloy wheels produced by a large European manufacturer are distinguished by their superior optics, stability and long lifetimes. Being able to meet the high standards of automotive manufacturers an ultra-modern surface treatment technology is of outmost importance. Here, proper water treatment plays a main role ...
Demineralized water for textile humidification
Humidifiers are used in textile processing to maintain product weight, improve quality, reduce static and provide air cooling. In order to ensure a continous and troble-free operation of the humidifiers, SILHORKO-EUROWATER has supplied a reverse osmosis unit producing demineralized water to Lainière de Picardie BC
Pre-treatment of aluminum by DI water
The pre-treatment is the foundation to achieve a good final result when applying powder coating. The surface pre-treatment at Indulak in Denmark is handled in a 56 meter long spray tunnel. The treatment is done according to the GSB AL 631 standard. The aluminum go through six treatment steps.
Rinse water for surface treatment of aluminum spray cans
The customer, Ball Aerocan, is a global leading supplier of extruded aluminum aerosol spray cans.
For the pretreatment process, demineralized rinse water with low conductivity has been required.
Ingredient water for ice cream production
Rud is the leading ice cream company in Ukraine, and their products are exported to a lot of European countries. The company strives for a continuous environmental improvement in the production, in which utilization of the water is an important part.
Rud needed water treatment for product water for the ice cream production as well as water for r...
Iron removal filters in stainless steel
The waterworks has been updated with new and modern water treatment equipment, including: 1) Pressure filters in stainless steel, 2) Aeration equipment and equipment for backwash, 3) Monitoring panel for online measurement of turbidity, oxygen, pH and conductivity, 4) Distribution system with frequency controlled booster pumps and 5) Pipe system in...
High purity water for biotech company Glycom
The customer is Glycom, a privately held research-based biotech company focused on human milk oligosaccharides (HMOs). The water is used as a processing aid and for cleaning operations in the HMO process. In each case, the purity of the water is very important for obtaining a good performance.
Complete production plant for purified water
At the firm of Fertin Pharma, SILHORKO-EUROWATER has supplied, installed and commissioned a water treatment plant for purified water production used for cleaning purposes and for manufacturing of medicated chewing gum.
Plug-and-play water treatment (WTP-F) for power plant
SILHORKO-EUROWATER has supplied a water treatment plant for the Tilbury Green Power Waste Wood Biomass Plant. Commissioning on site was done in 2 days. A true plug and play solution. The steam blow, an important milestone in the project, was accomplished as planned.
Water treatment for Combined Cycle Gas Turbine
EUROWATER has supplied water treatment for Poland's largest Combined Cycle Gas Turbine with a generation capacity of 400 MVe and 240 MWt, located in the town of Stalowa Wola.
This project is one of the first state-of-the art large CCGT gas fired power projects in Poland and part of Poland's drive to reduce reliance on use of coal for power gener...
Chemical free makeup water for power plant
Energie Steiermark Power Plant in Graz has replaced their existing water treatment plant for producing make-up water. One of their main concerns was to avoid the use of chemicals. By using a double pass RO, membrane degasser and EDI from EUROWATER, ultrapure water of a very high quality is produced.
DI rinse water for surface treatment
The customer is one of the largest producers of shock absorbers for the automotive industry.
In the surface coating process, rinse water of high quality is very important, and the demand was demineralized water with low conductivity. Water treatment was designed, produced, supplied and installed by SILHORKO-EUROWATER, including double pass rever...
UPCORE demineralization plant for boiler house and gelatine production
A gelatine manufacturer, belonging to the Weishardt Group, has replaced their water treatment in the boiler house with a water treatment plant from SILHORKO-EUROWATER.
300 m³/h filtration of groundwater for starch production
The water treatment solution consists of pressure filters for removal of iron and manganese from own groundwater supply. After filtration, the water is used as drinking water and inlet water for existing, larger softening plant, also supplied by SILHORKO-EUROWATER. The water is used in the refinement of starch products for food applications, mainly...
Rinse water for surface treatment in the automotive industry
The customer is a leading supplier for premium cars. In their paint shop they use cathodic electrodeposition (KTL/CED). For the production of DI rinse water, 20 years old demineralizers with co-current regeneration was replaced with UPCORE technology mainly because of the self-cleaning system ensuring a constant, low pressure loss and trouble-free ...
Boiler water treatment through UPCORE demineralization
The plant consists of UPCORE units for demineralization as well as mixed bed units for polishing. The ion exchange demineralizers are countercurrently regenerated, thus optimizing the utilization of the regeneration chemicals and self-cleaning, thus ensuring a constant, low pressure loss.
Danish waterworks monitors water quality on-line ensuring high reliability of supply
EUROWATER has supplied the process plant for this ultra-modern waterworks. That utilizes the newest technologies for online measurement, aeration and pressure filtration to ensure high securrity of supply and drinking water safety.
Sand filters with sea water resistant rubber lining
EUROWATER delivered a new filter solution to the combined heat and power plant, Avedøre Power Station, owned by DONG Energy A/S. The power plant uses desalinated water as boiler feed water. As part of the water treatment before the desalination plant, sand filtration is used.
Water treatment for sugar production
EUROWATER has delivered water treatment plant for a sugar factory in Ukraine. The old sugar plant reconstructed its facilities. There was a change of steam turbine into a new one. A complete solution for ultra pure water is supplied. Raw water is underground water from 3 wells and is undergoing the following treatment steps: 1) Iron removal 2) Soft...
Water for high pressure boilers with steam turbine
EC Gliwice is the strategic, local supplier of district heating for industrial and public buildings with a generation capacity of 67 MWt.
SFW Energia needed to expand the power generation module. Installation of a steam turbine introduced the need to use water in accordance with the standards PN-EN 12952-10 and PN-EN 12952-12.
The water treat...
Handrup Bakker Waterworks
EUROWATER has supplied the complete water treatment plant for this fine waterworks. The architect-designed waterworks was constructed and built to meet the requirements of the local area development plan and at the same time to pay due respect to nature conservation and the unique surrounding environment.
Water saving water treatment plant for boiler house
Design, manufacturing, supply and installation of water treatment plant for boiler feed water. The customer is a well-known company in the plastic industry.
Iron removal, softening and membrane filtration for food industry
The customers production capacity was doubled, also meaning that water treatment needed extension. Therefore SILHORKO-EUROWATER installed two iron removal filters followed by a duplex softening unit to treat a nominal flow of 100 m³/h.
Optimal water treatment for district heating plant in Denmark
SILHORKO-EUROWATER has delivered a complete water treatment plant for make-up water for the district heating plant. Optimal water for make-up and circuit is demineralized, deoxidated, free from mechanical impurities and pH regulated. By removing salts and oxygen, you avoid corrosion in the district heating piping.
Demineralized water for plant nursery specialized in seedlings
The customer is a plant nursery producing all kinds of seedlings. Demineralized water is used in a washing machine for plastic transport boxes for the seedlings, partly as rinse water and partly for dilution water for a disinfectant.
Water treatment for hygienic washing of textiles
SILHORKO-EUROWATER A/S has designed, produced, supplied, and installed a complete water treatment plant for producing water for washing of textiles and boiler feed water.
Short delivery time of solution for high pressure steam boiler makeup water
For one of Nordic Sugar’s factories, EUROWATER has delivered a complete and reliable water treatment plant for producing very high quality boiler makeup water. There are two boilers both with an operating pressure of 60 bar and the steam will drive a turbine that supplies the factory with power. In addition, the water is mixed with an ammonia solut...
Water treatment for cooling system at production of cables
The world leader in the production of cables and systems for telecommunications and energy is expanding its existing production capacity to its new facility in an emerging industrial park and needs for his manufacturing process pure cooling water with strictly defined properties. EUROWATER has supplied a modern, fully automated water treatment plan...
Clean water tanks in stainless steel
The clean water tanks are manufactured in stainless steel AISI 316L. The horizontal cylindrical tanks are free-standing in the building. This solution supports high drinking water safety based on some specific advantages compared to clean water tanks in concrete under ground.
Ultrapure water for microelectronic
SILHORKO-EUROWATER has supplied water treatment units with PVDF-HP pipe system for ultrapure water. The project is the biggest Polish investment in high technologies.
There are four units in the solution, all supplied as complete frame-mounted water treatment plants (WTP-F) with all internal piping in PVDF HP and wiring factory built
Turnkey solution for softened and demineralized water for hospital
EUROWATER has designed and supplied a complete frame mounted plant for the New University Hospital in Aarhus (DNU), Denmark. Supplied as a turnkey solution, EUROWATER had complete responsibility for delivery, installation, instrumentation, piping, control, and documentation. The pre-installation means that all internal piping and wiring have been ...
Water and energy saving upgrade for existing RO plant at voestalpine Polynorm B.V.
One of Western Europe's major supplier of automotive body and structural parts, voestalpine Polynorm B.V., has upgraded their existing water treatment plant. Due to increased production capacity, increased supply of demineralized water for the rinsing basins was needed. In addition, it was required that the upgrade had to respect strict space const...
Flexible solution with double pass RO for surface treatment
Design, manufacturing, supply and installation of water treatment solution for a surface treatment plant. The customer is a sub-supplier for the commercial vehicle industry.The reverse osmosis unit is normally operated as double pass. If a larger quantity of treated water is needed, the unit can be operated in parallel mode as two single pass units...
High efficiency production of makeup water for Aalborg district heating
EUROWATER has designed and supplied a new plant for producing makeup water for the district heating grid in Aalborg, Denmark. The plant is a vital part of Aalborg district heating's maintenance plan, allowing the main makeup production facility at another location to be shut down on a regular basis for maintenance. The plant consists of an UPCORE d...
Iron removal in pressure filters with flow rate of 135 m3/h
SILHORKO-EUROWATER has been involved in the construction of a complete new waterworks. The project included design, production, delivery, installation, and start-up of the pressure filters including stainless steel piping.
The pressure filters are designed for iron removal and manganese removal. The filters are high-capacity with a flow rate of ...
Water saving UPCORE softener for Heinz
SILHORKO-EUROWATER has delivered an UPCORE DUPLEX softening plant for Heinz in Poland, who uses soft water for vegetable preserves production.
The water treatment plant is needed for production, storage, distribution and water mixing system. Using the UPCORE softener results in a higher quality of water compared to a standard softener. It also s...
Water saving in Arla Dairy
New water saving technology from EUROWATER has reduced water waste by more than 75% to the benefit of both the dairy's competitiveness and the environment.
When the Danish Arla dairy needed to change and modernize their existing water treatment plant, sustainable dairy production played a major role. Therefore water savings was in high focus, an...
Pressure filters in stainless steel AISI 316 for Hasselager-Kolt waterworks
SILHORKO-EUROWATER has delivered pressure filters in stainless steel for the Danish waterworks Hasselager-Kolt.
The groundwater is oxidized with air from a compressor. It is then filtered through pressure filters to remove iron and manganese.
Demineralization with UPCORE technology
The plant consists of a raw water tank, two UPCORE units and two regeneration tanks. The boiler feed water is demineralized by the patented water treatment principle of UPCORE, combining all the know advantages of demineralization through iron exchanges with the counter-flow principle. The plant is self-cleaning, which reduces its pressure loss.
Double-pass RO in stainless steel for cosmetics
For one of the biggest cosmetic manufacturer in the beauty industry worldwide, EUROWATER has designed, built and erected fully automatic water treatment plant for production of cosmetics.
Make-up water for district heating
For company PGNiG, EUROWATER has designed, built and erected fully automatic water treatment plant for generation, storage and distribution of water for make-up of district heating system as well as boiler feed.
Water savings in food production with RO-PLUS
A leading nutrition company has upgraded their 19 years old reverse osmosis unit with the water-saving solution RO-PLUS.
Flue gas condensate treatment at biomass fired CHP plant
The flue gas condensate from a power plant in Sweden is treated by water treatment technologies from EUROWATER. The produced flue gas condensate is waste water that is contaminated with heavy metals and organic pollutants. Several treatment steps are required in order to release the purified water to recipient. The water treatment plant is designed...
Redundant reverse osmosis for the production of beer
Two redundant reverse osmosis units are producing each 30 m³/h for the production of beer. An automatic mixing bypass over the reverse osmosis makes sure the perfect amount of hardness is reached in the produced water.
Water treatment for PepsiCo dairy
The Wimm-Bill-Dann dairy in Kiev, Ukraine - owned by PepsiCo - has recently updated and improved the water treatment plant supplying high-quality demineralized water for the production of dairy products. The state-of-the-art water treatment plant with RO and automatic CIP is supplied by EUROWATER.
UV disinfection for treatment of drinking water
SILHORKO-EUROWATER has delivered UV-disinfection plants for Bagsværd waterworks in Denmark, which supplies the citizens of Gladsaxe with 1.2 million cubic metres of water every year.
The UV-treatment serves as an extra precaution to prevent microbiological contamination of the water. The risk of contamination is small, but the consequents woul...
Water for the steam turbines at Kyndby Power Plant
Kyndby Power Plant, which is owned by DONG Energy, is the emergency and peak load facility for all of Zealand. The power plant can be started up within minutes if operational irregularities occur in the high voltage electricity grid or problems arise at other power plants. Therefore, a reliable water treatment plant is crucial.
Design, manufacturing and supply of water treatment plant for waterworks in Krośniewice, a town in the center of Poland.
The filtration system consists of four automatic pressure filters with a diameter of 1800 mm, designed as parallel filters, with complete pipe system in stainless steel.
Chemical free makeup water for power plant
Renosyd I/S, waste-to-energy heat and powerplant located in Skanderborg in Denmark has replaced their existing water treatment plant for make-up water. One of their main concerns was to avoid the use of chemicals. By using a membrane degasser to remove CO2 instead of dosing lye, and by using EDI for producing deionate instead of a conventional mixe...
Make-up water for district heating grid BTB Schöneweide
SILHORKO-EUROWATER has delivered a compact unit type CU:RO for BTB Schöneweide in Germany.
In the compact system, consisting of a frame-mounted duplex-softening and a reverse osmosis system, the water from a well is softened, demineralized and subsequently fed into a network expansion tank. Sodium hydroxide solution is added to control pH.
Make-up water for district heating plant
On an exisiting water treatment plant an old reverse osmosis plant has been replaced by two new parallel systems. The soft water pump and permeate pump were upgraded to double redundant pumps.
Managment and control technology was also included in the expansion.
Process water for production of soft drinks
EUROWATER designed, manufactured, delivered and installed a water treatment plant for demineralization of water with controlled mixing to obtain requested m-alkalinity value in treated outlet stream used for production of soft drinks.
Water treatment for Olympic Ice
EUROWATER has supplied water treatment for the Sochi 2014 Olympic Winter Games. The water treatment ensures the highest quality speed skating ice completely free of particles, bubbles and salts.
Water treatment for a dairy plant
A change in the water quality from the municipal drinking water made the water harder. Because of the change in hardness, they needed to start to treat the intake water to the dairy with a softening plant.
Modernisation of softener for brew water
EUROWATER designed and retrofitted a worn out regeneration system for operation of softeners into a modern automated one with high level of operational reliability ensured by pneumatic activators of membrane valves system resulting in significant running cost savings.
Flue gas condensate treatment at waste incineration plant
The flue gas condensate from a waste-to-energy (WtE) plant is treated by water treatment technologies from EUROWATER. The water treatment plants are designed for a flow of 3.3 m³/h
Waterworks of the future - Truelsbjerg Waterworks
The new waterworks in Truelsbjerg, Denmark has from the very beginning been developed as an innovative and visionary way of designing waterworks for the future. Aarhus Vand, one of the major water utility companies in Denmark, wanted the waterworks to meet the requirements of today as well as those 20 or 30 years from now in regards to both water q...
Iron removal plant for mink farm
Availability of a continuous supply of clean and safe drinking water is important for ensuring good growth conditions and high fur quality of the animals at the mink farm in the central part of Ukraine.
Raw water is well water and contains high level of iron. Based on water analysis and customer requirements for working conditions, EUROWATER has d...
Water and energy efficient water treatment for large hospital
This hospital has gained considerable savings due to a reduced water, salt and energy consumption. Compared to the previous installation they save more than 10.000 m³ water per year. The hospital requires a reliable and robust water treatment and it has been important to exploit new and energy efficient technologies in order to minimize the consump...
Water treatment for an Arla / Molvest dairy in Russia
Danish Dairy company Arla decided to establish a new production in the southwest of Russia together with the local dairy Molvest. To reduce the levels of iron and manganese the feed water is filtered in two parallel pressure filters. The treated water is collected in large stainless steel vessels and a pumping unit supplies it to the user points. T...
50 m³/h continuous supply of ultrapure water for chemical production
Induss IV: This project is a fully remote controlled water treatment plant that delivers 50 m³/h of ultrapure water, mainly for ingredient water in the production of chemicals but also partly as boiler feed water. The water is treated with RO followed by an EDI polishing and stored in a 2000 m³ buffer tank to compensate for variation in usage durin...
Straight forward waterworks
When it was time to replace the existing EUROWATER pressure filter from 1969 Skræm Waterworks, from the northern part of Jutland, contacted EUROWATER which projected a waterworks and delivered the technical installation. Skræm Waterworks is a small decentralized waterworks with 80 consumers. The waterworks is 73 m² and designed with a filter room, ...
Plug-and-play water treatment plant for biomass gasification plant
This water treatment plant is designed mainly for producing ultrapure make-up water for a high-pressure steam boiler. The plant is supplied to Göteborg Energi AB for the GoBiGas project, a 20 megawatt biomass gasification and methanation project in Gothenburg, Sweden.
EUROWATER has built a waterworks on the Danish island Funen for removal of methane, iron, manganese and ammonium. The result is one of Denmark's most modern waterworks. Before the filtration process begins the content of methane is removed by degassing in an underground filter. The content of iron, manganese and ammonium is then removed by filtrati...
Water treatment for Facebook datacenter
EUROWATER has supplied and installed a water treatment plant for Facebook's server farm in the northern part of Sweden. To make the server farm as efficient as possible, cooling with water atomization was chosen instead of more traditional cooling methods. One of the benefits of water atomization is to achieve a high humidity, thus reducing static ...
Softened and demineralized water for catering company
The water treatment plant is designed for two applications: The first application is softened water for washing machines. The second application is demineralized water for dish washing machines and ingredient water for food production.
Waterworks for 500 m³/h
Water treatment plant for waterworks in Wyszków, a town in northeastern Poland. EUROWATERs has designed, manufactured, supplied and installed the complete solution.
The filtration system consists of six pressure filters with a diameter of 3000 mm designed as parallel filters with a pipe system entirely in stainless steel.
In the countryside just outside Aarhus, Denmark you will find this elegant, architect-designed waterworks with two separate filter lines sharing backwash equipment. The waterworks has been stylishly designed, but great care has been taken to ensure user friendly access to the technical installation for the sake of service and trouble-free operation...
Demineralized cooling water for alu die casting
alu-druckguss deliver machined and pre-assembled aluminum components and they process around 5,000-tons aluminum annually.
For their high-quality aluminum die casting they need demineralized water for dilution of coolants. Using demineralized water compared to city water is more economical – the use of coolants is reduced, the destruction of the...
Cooling water treatment installed in 8 foot container
SILHORKO-EUROWATER has delivered cooling water treatment for a chemical company in Russia, the company chose a plug-and-play 8-foot container installation for the water treatment.
Water from a well is filtered through a protective filter and subsequently softened. Automatic operation is ensured by the SE20 control panel, which communicates with...
Demineralized make-up water for district heating network
SILHORKO-EUROWATER has delivered water treatment plants for demineralized make-up water for the district heating network. To prevent corrosion, the circuit water of the district heating network is conditioned with an alkalinizing agent and an oxygen binder.
Demineralized cooling water for pit furnace
EUROWATER has designed and delivered a complete water treatment solution for production of demineralized cooling water for pit furnace used in copper recycle process.
Compact water treatment unit for pharma
The CU:PHARMA unit with RO and EDI is hot water sanitizable (HWS) for production of purified water (PW) at pharmaceutical company in Gdansk, Poland.
Plug and play solution for boiler feed water - water treatment plant in container
A high content of silica in the raw water resulted in scaling in the boiler. Based on a water analysis a suitable water treatment solution was designed including reverse osmosis unit and antiscale dosing as pretreatment. For optimum reliability in the water supply, the solution is designed with two individual and identical water treatment lines, ea...
Denmark’s largest and most modern UV disinfection system for drinking water
EUROWATER has supplied a large UV disinfection system to a municipal water utility close to Copenhagen. The water utility annually produces approximately 7 million m³ of water and supplies approximately 200,000 consumers with pure drinking water. The UV treatment is an extra security against microbiological contamination of the drinking water. The ...
Long life softener for heating plant
Softening units are a long-time investment and EUROWATER uses the best materials available. That is why the existing water softener at a Danish heating plant was still running after 20 years. It was only due to a major renovation that it was decided to replace the existing plant with a newer model. According to the operator, it easily could have ru...
Permeate softener in boiler feed water solution
The water supply is drinking water, prefiltered river water. The treated water is used as boiler feed water at CHP plant.
Demineralized make-up water for bioenergy plant
The biomass fired combined heat and power plant GBE- Gocher Bioenergie GmbH by the city Goch in Germany supplies climate friendly power for 11.000 households, and process steam for the company Nähr-Engel per year. It is fueled by natural wood, and 17 ton goes in to the combustion every hour.
Water treatment for V&S Absolute Spirits
SILHORKO EUROWATER has delivered a water treatment plant for V&S Absolute in Poland. The plant consists of hot water sanitixable actived carbon filters and pipe system in stainless steel and two reverse osmosis (RO) units placed on the same frame. Through RO you demineralize the water without the use of hydrochloric acid and sodium hydroxide.
Demineralized water for brewery at low water and energy consumption
In order to minimize water and energy consumption, Harboes breweries have thoroughly upgraded their water treatment plant. EUROWATER has supplied, installed and commissioned a series of reverse osmosis units – the RO-PLUS. This series is interesting because it is designed for a recovery of up to 90 % compromising neither reliability nor water quali...
Waterworks with an expansion plan for the future
The waterworks is build for a capacity of 70 m3/h. The customer wanted to prepare the waterworks for an increased future supply, so the filter room is designed for two extra pressure filters, an additional supply pump and piping for an extra clean water tank.
Recycling of backwash water for fine sand bed at waterworks
The anticipation of increased drainage fees prompted the private waterworks to investigate a more economical solution than flushing their rinse water directly to the drain. The waterworks produces 60 m3 of potable water per hour which requires a large amount of water for backwash. An operational calculation revealed that installing a separate press...
Compact RO plant with high recovery and low energy consumption
After having bought their steam from a neighboring company for a number of years, the customer was looking to start its own steam production instead. In collaboration with the boiler manufacturer it was determined that the customer needed up to 20 m³ of high quality treated water per hour with a conductivity less than 20 µS/cm.Due to the increasing...
Make-up water for high-pressure steam boiler 2 x 30 m³/h
The water source is a river with high salt content, especially chlorides. The level of organics in the raw water varies considerably during the year. Pre-treatment has been designed
to secure an acceptable water quality as inlet water for the demineralization plant. In the RO units, fouling resistant membranes have been applied in order to avoid b...
Rinse water for surface treatment at SEB group factory
The world leader in non-stick cookware and a world leader in irons, cooking appliances, pressure cookers, food and drink preparation products and scales, has specialised in surface treating frying pans and other cookware with teflon coating. EUROWATER has supplied and installed the water treatment plant for the surface treatment facility in France....
Boiler water treatment for Stadtwerke Brandenburg
Stadtwerke Brandenburg delivers gas, electricity and district heating for Brandenburg with a focus on profitability and sustainability.
The water is used as boiler feed water for high pressure steam boiler. The water is treated in five steps.
Water for cellulose production
SILHORKO-EUROWATER has delivered a water treatment plant for a chemical company with high demands on the reliability and water quality, and a special attention on silicic acid and conductivity.
The water is softened and afterwards demineralized through double-pass reverse osmosis. Using a double-pass RO system compared to a single-pass system re...
40 feet container-mounted reverse osmosis unit
Two reverse osmosis units are producing each 25 m³/h. All units as well as electrical cabinets are built up redundant inside a 40 feet container. The main flow goes to a chemical company where water is being used for process applications. A second flow of demineralized water goes through a duplex softener to take away the residual hardness before i...
Central water treatment plant for boiler feed, cooling and process
The customer is a technology leader in transforming steel wire and applying advanced coating know-how. In the process of adding new production lines to the facility, it was decided to optimize the supply of different water qualities by building a centralized water treatment plant.
Superior cooling water for gas turbines at peaking power plant
Automatic water treatment plant for production of demineralized cooling water of the highest quality to a system with gas turbines of total installed power of 2 x 50 MW. The water is injected into the gas engines to increase the power output of the gas turbines by cooling the combustion air.
Double pass RO for Boiler Feed Water
The unit RO-plus has a total recovery of 90% and is designed so that the mode of operation can easily be changed from double pass to two single pass.
Water treatment for Berlin airport
SILHORKO-EUROWATER has delivered water treatment for a German airport. The city-water is demineralized by two parallel reverse osmosis systems (RO). To avoid hardness precipitation antiscalant is added before RO. Different water qualities are used as make-up water for the district heating network and the cooling towers. The circulation water of the...
Water treatment plant for a newspaper printing company
In a printing house in Bratislava, SILHORKO-EUROWATER has installed a central water treatment plant to satisfy different needs for treated water. The advantages are savings in investment and operational expenses.
Arsenic removal 2 x 50 m³/h
A turnkey contract, this waterworks is uncompromisingly designed for optimum delivery reliability and low maintenance. Built as two completely separate waterworks supplied by separate wells and controlled by separate PLC control cabinets, it even has two separate clean water tanks.
Water treatment for glass washing machines
All-in-one! Fully automated, plug-and-play compact water treatment unit for rinsing zones. Demineralized rinse water and water savings by recirculating through special dual filter with gravel and activated carbon.
Turbine water, cooling water and drinking water at power plant
EUROWATER has supplied the power plant with a.o. pressure filter, activated carbon filter, UV-disinfection unit, reverse osmosis units, cartridge filter, electrodeionization unit, and mixed-bed unit. The flow rate for turbine water is 1.5 m³/h, for the cooling water 7.5 m³/h, and for the drinking water 2.0 m³/h.
Make-up water for high-pressure boiler in power plant
Minimizing installation time and labour at customer premises can be achieved by a EUROWATER frame-mounted water treatment system. Frame-mounted units are supplied with all internal piping and wiring ready made and the system is pretested.
2 x 60 m³/h ultrapure water for power plant - WTP in 6 x 40’ containers
This customer needed to upgrade the existing water treatment plant, but no free space at site was available. Also, the construction works on site was requested to be minimized. It was decided to order the equipment built inside 40’ containers. Site installation was reduced to the pipe system and the electrical wiring between the containers.
Make-up water for heat and power plant
The combined heat and power plant in Randers has replaced their existing water treatment plant with new and modern equipment. Make-up water of best quality is produced, which ensures electricity and heating to competitive prices.
Pharmaceutical double pass RO for dialysis application
Demineralized water is being produced with a double pass reverse osmosis unit to ensure an end conductivity of less than 5 µS/cm. This pure water is being used to prepare the dialysate needed for hemodialysis.
5.6 m3/h feed water for high-pressure boiler at CHP
A frame-mounted water treatment solution from EUROWATER gives the customer a safety due to the fact that the plant is complete with all internal piping and wiring factory-built, and that the whole plant has been performance and pressure tested in our factory. In this case, the units were mounted on two hot-galvanized frames for easy transportation....